Thanks for the offer.I may be able to help then. Let me know what you need. Regards, M
MY OB11 doesn't show a fault however, my independent garage with a Bosch diagnostic get a fault code for flaps. They are seeking advice before they revert to me. I have had a quiet moment to listen to the flaps and you can hear them moving (or trying to move). Despite coming up to temp the fan has not worked. Suspect garage will revert with a couple of options. Any suggestions here welcomed.
I have been driving the car with no heating fan running and no temperature gauge working over the past few days and have discovered that the side vents get warm after a period of time, especially if I crack he windows open a bit.
Also, if I set the flaps to the up position with the controls on the dash the centre vents will get warm too.
So, at least for me I do thik that these flaps are working.
I have had to use a squeegee on the inside of the windscreen to 'demist' it before I can drive as it does not demist by the windscreen vent for quite a while after starting to drive it.
I am taking it to the garage tomorrow to ask for the sensor and thermostat to be replaced and work from there.
Not going down another avenue Andy, I have had the sensor and thermostat replaced, but the fan was still not turning, the fan motor is broke (readily available replacement) and the "fan speed controller" (for want of a better description) AKA "climactic control unit" (possibly not the correct technical term) also needs replacing, this part apparently is not readily available hence the request.
A wiring fault was also fixed (ABE).
Sorry for the brevity of my last post.
Thanks for the offer.
I have ordered the unit from eBay I mentioned in this thread
https://www.a2oc.net/community/index.php?threads/cabin-heater-not-working.34508/
The seller confirmed that it is one from a car with climate control, I hope it's the right part.
I can't read the part number from the image on eBay but have seen others wit the part number 8Z0959501 that look just the same.
Do you have any Idea whether it would be the correct part for my car?
I still have not ordered a blower/fan motor, there are some on eBay listed as part No. 6q2819015g for £15 but that sounds just too cheap.
Do you know if this would be the correct part for my car?
So, that part actually has nothing to do with the 'cabin' heater fan/blower?If I'm following this thread correctly it looks like the fan controller being discussed is the finned unit for the radiator fan.
OK, That is probably the part that I need then?For the 'cabin' fan controller
check item 10 on this parts diagram - https://audi.7zap.com/en/rdw/audi+a2/a2/2003-248/8/820-820010/
Do they vary enough not to be able to be fitted/used between different models?I have a 03 1.4tdi 75ps
The part number for my blower motor is 6q2820015e they vary between models even though they look very similar. You wouldn’t be able to tell unless you pull yours out and look unfortunately.
I had a look and after getting the glove box out I could see the part number without removing the blower motor, it is 6q2820015c.I have a 03 1.4tdi 75ps
The part number for my blower motor is 6q2820015e they vary between models even though they look very similar. You wouldn’t be able to tell unless you pull yours out and look unfortunately.